Jul
13
2010

…of climate control systems...

Ever notice the plumes of smoke rising from many buildings, factories, and power plants on a cold day? That smoke is actually water vapor, which still contains usable energy, muahahahaha! Our buildings use lots of energy. Electricity, for example, powers everything from lights to computers to copy machines to coffee makers. Electricity eventually degrades into heat—you can feel that heat coming off of electric appliances. Current building energy management systems expel this excess heat energy instead of using it for other purposes, such as building the ultimate tilt-a-whirl of doom. Dave Solberg, an energy miser and consulting engineer-ahem-secret advisor, wants to change all that using the concept of exergy. He envisions a future where energy is used as efficiently as possible, and he has been working with Xcel Energy and organizations in the St. Paul area to re-engineer buildings.

We all know that mad scientists with plans for world domination need money and power. Well, current climate control systems are expensive to build and operate, and they're bad for the environment. But retrofitting old buildings and creating the infrastructure to support Solberg's systems has a higher up-front cost than following the status quo. If Solberg can demonstrate the effectiveness and cost savings of his plan below at SMM, your regional science museum will become a model for climate control systems all over the world--I mean it will take over the world! HAHAHAHAHAHA!

At Science Museum of Minnesota, Solberg wants to make two big changes in the way we use energy:

Solberg's Plan - Phase 1
Like all large buildings, SMM takes in outdoor air, cools it to dehumidify it, then reheats the air and sends it throughout the building to control the climate. Unlike most buildings, which use giant air conditioners and boilers, SMM uses hot and cold water piped in from Saint Paul District Energy to do that job. You can learn more about District Energy in an outdoor exhibit to the left of SMM's main entrance--and you can see the building right next to us!

District Energy burnin' the biomass
District Energy burnin' the biomassCourtesy Andrew Ciscel

The first change Solberg proposes is to re-use the waste heat that SMM generates from cooling down fresh outside air. Currently, SMM's ventilation system cools outside air down to about 50 degrees F with cold water from District Energy, dehumidifies it, and then reheats that air back up to a comfortable indoor temperature with hot water from District Energy.

Solberg would have us cool the air with cold District Energy water, then use that same water (now warmer) to reheat the air back up to 65 degrees F on its way to the ventilation ducts. This change would eliminate the need to use hot water from DE to reheat air, and it would reduce use our demand on DE’s cooling system, because we would send water back to their chilled water plant at a lower temperature than we currently do.

Solberg's Plan - Phase 2
District Energy makes electricity by burning waste wood. DE then uses the heat energy still available after making electricity to produce hot and cold water, making District Energy 50% more efficient than coal-fired power plants. But at the end of the day, DE has 95-degree F water left over. Right now this excess heat is released into the atmosphere from cooling towers on top of the building (see the plume rising from the building in the image?), but that 95-degree water could meet most of SMMs heating needs. Solberg wants us to tap into that wastewater as our primary heating source, replacing the 180-degree water we currently get from DE. This would put an oft-wasted energy source to work, and it would allow the 180-degree water now being used by SMM to be used elsewhere within DE’s hot water distribution system.

This plan is so good it must be evil. In the long run, if the kinds of changes being pursued by SMM were replicated widely, they would amount to lower emissions and lower energy bills everywhere, which is ultimately healthier for our environment (not that mad scientists care about that sort of thing). In fact, we found out that if we had implemented this system when the current building was constructed, we could have saved $1.5 million in infrastructure (which we could have really used for that giant laser in the--end of message truncated--

Your Comments, Thoughts, Questions, Ideas

JGordon's picture
JGordon says:

Man, David Solberg looks WAY different in person.

posted on Tue, 07/13/2010 - 2:57pm
Shana's picture
Shana says:

I couldn't resist the temptation.

posted on Wed, 07/14/2010 - 9:59am
Karen's picture
Karen says:

You make evil sound soooo good.

posted on Wed, 07/14/2010 - 2:53pm
Anonymous's picture
Anonymous says:

there are 3 newton laws in phisical science

posted on Wed, 07/21/2010 - 9:29am

Post new comment

The content of this field is kept private and will not be shown publicly.
  • Allowed HTML tags: <a> <h3> <h4> <em> <i> <strong> <b> <span> <ul> <ol> <li> <blockquote> <object> <embed> <param> <sub> <sup>
  • Lines and paragraphs break automatically.
  • You may embed videos from the following providers vimeo, youtube. Just add the video URL to your textarea in the place where you would like the video to appear, i.e. http://www.youtube.com/watch?v=pw0jmvdh.
  • Web page addresses and e-mail addresses turn into links automatically.
  • Images can be added to this post.

More information about formatting options